顶空-气相色谱法测定绞股蓝总苷中的溶剂残留

目的：建立顶空-气相色谱法测定绞股蓝总苷原料药中8种残留溶剂的分析方法。方法：采用顶空-毛细管气相色谱法，DB-WAX毛细管色谱柱（30 m×0.32 mm，0.25 μm），氢火焰离子化检测器，载气为氮气，流速1.5 mL·min^-1；柱温为程序升温，进样口温度为220℃，检测器温度为250℃。顶空进样，顶空平衡温度100℃，平衡时间为30 min，定量环温度105℃，传输管温度110℃，进样量1 mL，低速振摇。结果：测定的8种有机溶剂完全分离，线性关系良好。苯、甲苯、二甲苯、二乙烯苯、苯乙烯、甲醇、乙醇和正丁醇的平均回收率分别为96.9%、98.4%、96.6%、99.5%、96.8%、99.7%、98.4%和98.7%。8批样品中有6批的有机溶剂残留量均在规定的范围内，2批正丁醇和二乙烯苯残留量高于限度。结论：本方法可以较好地用于测定绞股蓝总苷中的残留溶剂。

Objective: To establish a GC method for the determination of residual solvents in gypenosides. Methods: The residual solvents in gypenosides were separated and detected by DB-WAX capillary column(30 m×0.32 mm,0.25 μm)with FID detector. The carried gas was nitrogen,and the gas flow rate was 1.5 mL·min^-1.The column temperature was programmed. The inlet temperature was 220℃ and FID detector temperature was set at 250℃.The split ratio was 10:1. Headspace conditions were as follows:the temperature and the time of balance for the sample were 100℃ and 30 min;the temperature of quantitative loop and transfer lines was 105℃ and 110℃,respectively.The sample volume was 1 mL,with low-speed shaking. Results: The 8 residual solvents tested were completely separated and the linear relationship was good. The average recoveries for benzene,toluene,xylene,divinylbenzene,styrene,methanol,ethanol and n-butanol were 96.9%,98.4%,96.6%,99.5%,96.8%,99.7%,98.1% and 98.7%,respectively. The residual amount of organic solvents in 6 batches was within the specified range,and the residual amount of 2 batches for n-butanol and divinylbenzene was above the limit. Conclusion: This method can be used to determine the residual solvents in gypenosides.

[1] 史琳.绞股蓝化学成分研究[D].沈阳:沈阳药科大学,2010 SHI L.Study on the Chemical Ingredients in Gynostemma[D].Shenyang:Shenyang Pharmaceutical University,2010
[2] 向善荣.中国绞股蓝研究与资源开发利用[M].南昌:江西高校出版社,1997. XIANG SR.Research and Resource Development and Utilization of Gynostemma pentaphyllum in China[M].Nanchang:Jiangxi University Press,1997
[3] 路安民,陈书坤.中国植物志[M].北京:科学出版社,2004,301. LU AM,CHEN SK.Flora of China[M].Beijing:Science Press,2004:301
[4] 朴香兰,吴倩.绞股蓝研究进展[J].时珍国医国药,2010,21(7):1758 PIAO XL,WU Q.Progressive studies on Gynostemma pentaphyllum[J].Lishizhen Med Mater Med Res,2010,21(7):1758
[5] 史琳,赵红,张璐雅,等.绞股蓝药理作用的研究进展[J].药物评价研究,2011,34(2):125 SHI L,ZHAO H,ZHANG LY,et al.Advances in studies on the pharmacological effects of Gynostemma pentaphyllum[J].Drug Eval Res,2011,34(2):125
[6] 霍珍.安康市绞股蓝专利状况分析[J].合作经济与科技,2017,10(19):102 HUO Z.Analysis on the patent status of Gynostemma pentaphyllum in ankang city[J].Cooper Econ Sci Technol,2017,10(19):102
[7] 谢艳丽,谭曜,周雪晴,等.气相色谱法测定伊潘立酮中丙酮、乙醇等多溶剂残留量[J].现代仪器,2012,18(1):17 XIE YL,TAN Y,ZHOU XQ,et al.Determination of residue of acetone and ethanol in epirinone by gas chromatography[J].Mod Instrum,2012,18(1):17
[8] 胡凤杨.顶空进样-气相色谱法测定植物提取物中17种有机溶剂残留[J].工程技术,2017,39(10):124 HU FY.Determination of residues of 17 organic solvents in plant extracts by headspace sampling and gas chromatography[J].Engin Technol,2017,39(10):124
[9] 哀海龙,李仙义,肖小河,等.D-101型大孔树脂残留物的顶空进样法分析研究[J].中药新药与临床药理,2003,14(2):121 AI HL,LI XY,XIAO XH,et al.Analysis of D-101 macroporous resin residues by headspace sampling method[J].Chin Med New Drug Clin Pharmacol,2003,14(2):121
[10] 周勇.气相色谱法测定大孔树脂有机残留物[J].淮海医药,2005,23(1):75 ZHOU Y.Determination of organic residues of macroporous resin by gas chromatography[J].Huaihai Pharm,2005,23(1):75
[11] 中华人民共和国药典2015年.四部[S].2015:105 ChP 2015.Vol IV[S].2015:105
[12] 仲海洁,胡军华,王晓娇,等.气相色谱法测定六味地黄背糖原料药中的7种残留溶剂[J].中国药房,2016,27(6):797 ZHONG HJ,HU JH,WANG XJ,et al.Determination of 7 kinds of residual solvents in Liuwei dihuang antisaccharide raw material by gas chromatography[J].China Pharm,2016,27(6):797
[13] 常增荣,傅欣彤,刘颖.顶空气相色谱法测定当药提取物中大孔树脂残留物[J].中国实验方剂学杂志,2013,19(16):153 CHANG ZR,FU XT,LIU Y.Determination of residue of macroporous resin in the extract by headspace gas chromatography[J].Chin J Expr Tradit Med Form,2013,19(16):153
[14] 徐小民,赵永信,宋国良,等.气质联用法测定保健品中二乙烯苯溶剂残留[J].中国卫生检验杂志,2008,18(8):1556 XUE XM,ZHAO YX,SONG GL,et al.Determination of the residue of divinyl benzene solvent in health products[J].Chin J Health Inspect,2008,18(8):1556
[15] 周宇艳,咸洋,程欲晓,等.液体顶空-气相色谱法测定食品接触苯乙烯聚合物中单体及溶剂残留[J].理化检验-化学分册,2012,48(3):257 ZHOU YY,XIAN Y,CHENG YX,et al.Determination of monomers and solvent residues in food contact styrene polymers by liquid headspace-gas chromatography[J].Phys Test Chem Anal Part B:Chem Anal,2012,48(3):257