1,_1,_1,_2-四氟乙烷中有关物质的气相色谱和质谱联用分析

目的: 用GC-MS和GC法对1,1,1,2-四氟乙烷中的有关物质进行定性、定量分析。 方法: GC色谱条件,采用DB-1301(120 m×0.25 mm×1 μm)色谱柱,载气为高纯氮气,进样口温度200℃,流速1 mL·min^-1 ,FID检测器温度180℃,柱温为程序升温(-20℃保持12 min,以10.0℃·min^-1速率升温到190℃,保持5 min,液氮冷却)。GC-MS条件的GC部分同上,质谱条件,载气为高纯氦气,70 eV,EI离子源,质量扫描范围为40~400 amu。 结果: 得到了有关物质的气相色谱图及相应的质谱图,对其进行解析,初步鉴定出各有关物质为2-氯-1,1,1-三氟乙烷;氟氯甲烷;2-氯-1,1,1,2-四氟丙烷;2-氯-1,1-二氟乙烯; 1,2-二氯-1,1,2,2-四氟乙烷;1,1-二氯-1,2,2,2-四氟乙烷;一氯二氟甲烷;1,1,2,2-四氟乙烷;1,1,1-三氟丙烯;1,1,1-三氟乙烷;1,1-二氟乙烷;氯五氟乙烷;五氟乙烷;氯氟乙烯。 结论: 为研究1,1,1,2-四氟乙烷用药安全及提高产品质量提供了科学依据。

Objective: To identify and quantify the related substances in 1,1,1,2- tetrafluoroethane by GC-MS and GC. Methods: The GC conditions were optimized as follows:DB-1301 capillary column (120 m×0.25 mm×1.0 μm), high purity nitrogen as carrier gas,injector temperature was 200℃,and the flow rate was 1 mL·min^-1,FID detector temperature was 180℃,column temperature was kept at -20℃ for 12 min,then rose to 190℃ at a rate of 10℃·min^-1 and maintained for 5 min. Liquid nitrogen was used for cooling down.The GC-MS conditions were as follows:High purity helium as carrier gas with electronic ionization EI,70 eV,ms scanning was set at the range of 40-400 amu. Results: The total GC chromatogram and mass spectra of each chromatographic peak were obtained and analyzed,the related substance HCFC-133a,HCFC-31,HCFC-124,HCFC-1122,CFC-114,CFC-114a,HCFC-22,HFC-134,HFC-1243zf,HFC-143a,HFC-152a,CFC-115,HFC-125,HCFC-1131a were identified. Conclusion: The present study provides a scientific basis for the medication safety analysis and quality improvement of 1,1,1,2- tetrafluoroethane.

1 GB/T 18826-2002,2003-04-01.1,1,1,2-Tetrafluoroethane for industrial use(工业用1,1,1,2一四氟乙烷(HFC-134a))[S]
2 WANG Qing(王青),SUN Feng-long(孙凤龙),WANG Wen-qing(王文清).Studies on the multiphoton ionization dissociation of HFC-152a and HFC-134a and the evaluation for their application prospects(氟里昂替代物HFC-134a 和HFC-152a 的多光子电离研究)[J].Chem J Chin Univ(高等学校化学学报),2002,8:1504
3 GUAN Wu-zhang(关屋章),SAN Qi-jin(三崎进),Research and development of a novel hydrofluorocarbon alkyl ether refrigeration(新制冷剂氢氟烷基醚的研究开发)[J].Organo-Fluorine Ind(有机氟工业),1996,3:33
4 Guidance for Industry-Metered Dose Inhaler(MDI)and Dry Powder Inhaler(DPI)Drug Products [DB/OL].[2013-09-23].http://www.fda.gov/down loads/drugs/guidance compliance-regulatory information/guidances/ucm 070573,pdf
5 GAO Hai(高海),LIU Hai-jing(刘海静),MA Peng-fei(马鹏飞),et al.GC-MS determination of related substances of tetrafluoroethane (GC-MS联用法测定四氟乙烷中的有关物质)[J].Chin J Pharm Anal(药物分析杂志),2008,28(12):2077
6 Siegl WO,Wallington TJ,Guenther MT,et al.R-134a emissions from vehicles[J].Environ Sci Technol,2002,36(4):561
7 Mcculloch,Archibald.Process for the preparation of 1,1,1,2-tetrafluorethane. [P].EP0379793B1.1993-03-10
8 Franklin IA,Victor WP,Stephen LW,et al.Efficient regioselective labelling of the CFC alternative 1,1,1,2-tetrafluoroethane (HFC-134a) with fluorine-18[J].J Fluorine Chem,1995,70(2):279
9 O'Doherty SJ, Nickless G, Bassford M,et al.Separation of hydrohalocarbons and chlorofluorocarbons using a cyclodextrin gas solid chromatography capillary column[J]. J Chromatogr A,1999,832(1-2):253
10 HANG Yong-ke(张永科),ZHAO Jing-chan(赵景婵),GUO Zhi-an(郭治安),et al.Qualitative and quantitative analyses of micro-impurities in medical HFC-134a (医用HFC.134a中微量杂质的定性、定量分析)[J].Chin J Appl Chem (应用化学),2007,24(11):1346
11 QUAN Heng-dao(权恒道),LI Hui-li(李惠黎).Study on synthesis of 1,1,1,2- tetrafluoroethane (1,1,1,2—四氟乙烷的合成研究) [J].J Nanjing Univ Sci Technol (Nat Sci),1997,3:253
12 TANG Yue-bing(唐岳兵).Code naming of fluorohydrocarbon substance(含氟烃的编码命名) [J].J Nanjing Univ Sci Technol(化工标准化与质量监督),2000,12:7